Sustainable Synthesis of Chitosan-SnO2 Nanocomposite for Enhanced Visible-Light Photocatalytic Degradation of Crystal Violet Dye
DOI:
https://doi.org/10.67364/z1fx2260Keywords:
CS-SnO₂ nanocomposite, Crystal Violet, PhotocatalysisAbstract
A chitosan–tin oxide (CS–SnO₂) nanocomposite was prepared by a co-precipitation-based approach and investigated for the visible-light-assisted removal of Crystal Violet (CV) dye from aqueous solution. The incorporation of chitosan was intended to provide additional adsorption sites and improve the dispersion of SnO₂ nanoparticles. The prepared nanocomposite was characterized using FT-IR, XRD, FE-SEM, EDS, TGA, and UV-Vis spectroscopy. XRD analysis indicated the formation of crystalline SnO₂ with an estimated crystallite size of 4.34 nm, while FE-SEM analysis showed an average particle size of 69.4 ± 13.6 nm. The optical band gap was estimated to be 3.40 eV for the CS–SnO₂ nanocomposite compared with 3.65 eV for SnO₂. The removal of CV was investigated as a function of catalyst dosage, initial dye concentration, temperature, pH, and irradiation time. A considerable contribution from adsorption was observed during the initial dark-equilibrium period. Under the investigated conditions, the highest CV removal efficiency of 97.5% was obtained at an initial dye concentration of 5 mg/L, catalyst dosage of 60 mg, pH 12, and 180 min of visible-light irradiation. The photocatalytic process followed an apparent pseudo-first-order kinetic model, with a rate constant of 0.0033 min⁻¹ at 5 mg/L CV. The catalyst also exhibited measurable reusability over four successive cycles, although a decrease in removal efficiency was observed during repeated use. The results demonstrate the potential of the CS–SnO₂ nanocomposite for combined adsorption and visible-light-assisted dye removal.
References
[1]I. Manisalidis, E. Stavropoulou, A. Stavropoulos, and E. Bezirtzoglou, “Environmental and Health Impacts of Air Pollution: A Review,” Front. Public Heal., vol. 8, p. 14, Feb. 2020, doi: 10.3389/fpubh.2020.00014.
[2]N. Bolan et al., “Remediation of heavy metal(loid)s contaminated soils – To mobilize or to immobilize?,” J. Hazard. Mater., vol. 266, pp. 141–166, Feb. 2014, doi: 10.1016/j.jhazmat.2013.12.018.
[3]N. Singh, U. Kumar, N. Jatav, and I. Sinha, “Photocatalytic Degradation of Crystal Violet on Cu, Zn Doped BiVO4 Particles,” Langmuir, vol. 40, no. 16, pp. 8450–8462, Apr. 2024, doi: 10.1021/acs.langmuir.3c04039.
[4]M. Sifat et al., “Photocatalytic Degradation of Crystal Violet (CV) Dye over Metal Oxide (MOx) Catalysts,” Catalysts, vol. 14, no. 6, p. 377, Jun. 2024, doi: 10.3390/catal14060377.
[5]C. Sun et al., “Recent intensification strategies of SnO2-based photocatalysts: A review,” Chem. Eng. J., vol. 427, p. 131564, Jan. 2022, doi: 10.1016/j.cej.2021.131564.
[6]Z. H. Alhalafi et al., “Study of photophysical properties, photodegradation breakdown cost and recycling processes of Zn/SnO 2 quantum dots via real industrial wastewater treatment,” Arab J Chem, vol. 19, p. 7562025, Feb. 2026, doi: 10.25259/AJC_756_2025.
[7]R. Román-Doval, S. P. Torres-Arellanes, A. Y. Tenorio-Barajas, A. Gómez-Sánchez, and A. A. Valencia-Lazcano, “Chitosan: Properties and Its Application in Agriculture in Context of Molecular Weight,” Polymers (Basel)., vol. 15, no. 13, p. 2867, Jun. 2023, doi: 10.3390/polym15132867.
[8]R. Mirzajani, N. Pourreza, and J. Burromandpiroze, “Synthesis of chitosan-SnO2 nanoparticles biocomposite for dispersive micro-solid phase extraction of iron in environmental and wastewater samples and its determination by microvolume spectrophotometric detection,” Desalin Water Treat, vol. 97, pp. 213–224, Nov. 2017, doi: 10.5004/dwt.2017.21536.
[9]E. M. Bakhsh, K. Akhtar, T. M. Fagieh, S. B. Khan, and A. M. Asiri, “Development of alginate@tin oxide–cobalt oxide nanocomposite based catalyst for the treatment of wastewater,” Int J Bio Macromol, vol. 187, pp. 386–398, Sep. 2021, doi: 10.1016/j.ijbiomac.2021.07.100.
[10]M. Kurzawa, K. Lewandowska, and A. Sionkowska, “Chitosan films with quercetin for skin applications,” Eng. Biomater., vol. 173, p. 4, 2025, doi: https://doi.org/10.34821/eng.biomat.173.2025.04.
[11]J. N. Obiefuna and V. N. Okafor, “Comparative Studies of the Physicochemical Properties of Chitosan from Commercial and Periwinkle Shell (CPS),” Chem. Res. Technol., vol. 1, no. 4, pp. 186–191, 2024, doi: https://doi.org/10.22034/chemrestec.2024.486304.1028.
[12]I. Onosakponome et al., “Extraction and FTIR spectra of chitin and chitosan produced from periwinkle (Tympanotonos fuscatus) under differential decolorization conditions,” Trop. J. Chem., vol. 1, no. 1, pp. 50–57, 2025.
[13]N. Maurmann et al., “Development of New Chitosan-Based Complex with Bioactive Molecules for Regenerative Medicine,” Futur. Pharmacol., vol. 4, no. 4, pp. 873–891, Dec. 2024, doi: 10.3390/futurepharmacol4040046.
[14]I. Aranaz et al., “Chitosan: An Overview of Its Properties and Applications,” Polymers (Basel)., vol. 13, no. 19, p. 3256, Sep. 2021, doi: 10.3390/polym13193256.
[15]S. A. Jasim, N. M. L. Al Maimuri, A. Hashim, M. H. Abbas, A. Hadi, and H. Ibrahim, “Fabrication and enhancing the features of chitosan/SnO2-ZnO nanocomposites films for optoelectronics and biological applications,” Trends Sci, vol. 22, no. 10, p. 10534, 2025, doi: https://doi.org/10.48048/tis.2025.10534.
[16]F. Almutairi et al., “Application of Chitosan/Alginate Nanocomposite Incorporated with Phycosynthesized Iron Nanoparticles for Efficient Remediation of Chromium,” Polymers (Basel)., vol. 13, no. 15, p. 2481, Jul. 2021, doi: 10.3390/polym13152481.
[17]S. Heydari and M. Moradi, “Green Synthesis of Nanochitosan/Bentonite/SnO2–ZnO Bionanocomposite for Removal of Heavy Metal Ions and Photocatalytic Degradation of Organic Dye,” J. Polym. Environ., vol. 32, no. 8, pp. 3698–3717, Aug. 2024, doi: 10.1007/s10924-023-03178-1.
[18]C. V Stevens, “Chitin and chitosan: Properties and applications,” 2020.
[19]K. J. A. Yao et al., “Optimization of the electrical conductivity of SnO2 by Taguchi design and sol-gel Route for perovskite solar cells,” Int. J. Thin Film Sci. Technol., vol. 15, no. 1, pp. 31–42, 2026, doi: 10.18576/ijtfst/150102.
[20]X. Liu and R. Sun, “Fabrication and properties of multifunctional sodium alginate/MXene/nano-hydroxyapatite hydrogel for potential bone defect repair,” J. Mater. Res. Technol., vol. 36, pp. 913–921, May 2025, doi: 10.1016/j.jmrt.2025.03.163.
[21]P.-O. Bussiere, J.-L. Gardette, G. Rapp, C. Masson, and S. Therias, “New insights into the mechanism of photodegradation of chitosan,” Carbohydr. Polym., vol. 259, p. 117715, May 2021, doi: 10.1016/j.carbpol.2021.117715.
[22]O. Guirguis, “Enhanced molecular structure, thermal stability, and linear/nonlinear optical characteristics of chitosan/titanium dioxide nanocomposite films,” May 21, 2024. doi: 10.21203/rs.3.rs-4399518/v1.
[23]M. El Mahamdi et al., “Effect of Substituents on Chitosan-Derived Sustainable Corrosion Inhibitors: Experimental and Computational Studies of Inhibition and Adsorption Performance,” Langmuir, vol. 40, no. 52, pp. 27396–27415, Dec. 2024, doi: 10.1021/acs.langmuir.4c03637.
[24]A. Sumaila, N. N. Onyirioha, D. O. Erhabor, and H. B. Muhammad, “Thermal and Morphological Studies on Biosynthesized Chitosan-Silver Nanocomposites,” J. Mater. Environ. Sci., 14 (6), 678, vol. 688, 2023.
[25]W. Oo, J. Hye Park, M. Zaw Win, and K. Bok Yi, “Dual preservative effects of SnO2-chitosan on Cu1+-doped boehmite composites for stable CO adsorption properties,” Sep. Purif. Technol., vol. 348, p. 127631, Nov. 2024, doi: 10.1016/j.seppur.2024.127631.
[26]R. K. Jana, S., Trivedi, M. K., Tallapragada, R. M., Branton, A., Trivedi, D., Nayak, G., & Mishra, “Characterization of Physicochemical and Thermal Properties of Chitosan and Sodium Alginate after Biofield Treatment,” Pharm Anal Acta, vol. 6, no. 10, 2015, doi: 10.4172/2153-2435.1000430.
[27]J. P. Singh and G. C. Joshi, “Structural, Optical and Electrical Properties of rGO@SnO2 Nanopowder Obtained via Chemical Co-precipitation Method,” J. Nano- Electron. Phys., vol. 14, no. 1, pp. 01028-1-01028–4, 2022, doi: 10.21272/jnep.14(1).01028.
[28]M. Shaban Tameh, W. L. Gladfelter, and J. D. Goodpaster, “Unraveling Surface Chemistry of SnO2 Through Formation of Charged Oxygen Species and Oxygen Vacancies,” Int J Quantum Chem, vol. 125, no. 4, Feb. 2025, doi: 10.1002/qua.70017.
[29]L. S. Alqarni, M. D. Alghamdi, A. A. Alshahrani, and A. M. Nassar, “Green Nanotechnology: Recent Research on Bioresource-Based Nanoparticle Synthesis and Applications,” J. Chem., vol. 2022, no. 1, pp. 1–31, Aug. 2022, doi: 10.1155/2022/4030999.
[30]A.-G. Niculescu and A. M. Grumezescu, “Applications of Chitosan-Alginate-Based Nanoparticles—An Up-to-Date Review,” Nanomaterials, vol. 12, no. 2, p. 186, Jan. 2022, doi: 10.3390/nano12020186.
[31]I. Uddin, T. U. Rahman, M. Said, E. Khan, and M. Ishaq, “Visible-light-assisted degradation of crystal violet using CuO- and ZnO-incorporated (Am- co -BA)@PVA hydrogel nanocomposites,” RSC Adv, vol. 16, no. 15, pp. 13332–13346, 2026, doi: 10.1039/D6RA00342G.
[32]R. K. Chougale et al., “Water-hyacinth-leaf-like 2D bismuth oxychloride photocatalyst for the degradation of methylene blue and crystal violet dyes,” RSC Adv, vol. 16, no. 18, pp. 16181–16193, 2026, doi: 10.1039/D6RA01208F.
[33]A. P. Kumar, D. Bilehal, A. Tadesse, and D. Kumar, “Photocatalytic degradation of organic dyes: Pd-γ-Al 2 O 3 and PdO-γ-Al 2 O 3 as potential photocatalysts,” RSC Adv, vol. 11, no. 11, pp. 6396–6406, 2021, doi: 10.1039/D0RA10290C.
[34]D. C. Onwudiwe, N. Gobile, O. A. Oyewo, and S. S. Makgato, “Photocatalytic reduction of hexavalent chromium using Zn2SnO4–ZnO modified g-C3N4 composite,” Results Eng, vol. 20, p. 101521, Dec. 2023, doi: 10.1016/j.rineng.2023.101521.
[35]K. Krishna Veni, S. Agalya, R. Kavitha, I. Fatimah, S. Sagadevan, and L. C. Nehru, “Efficient photocatalytic activity of chitosan/tin oxide nanocomposite for environmental remediation,” Inorg Chem Commun, vol. 154, p. 110865, Aug. 2023, doi: 10.1016/j.inoche.2023.110865.
[36]H. Roy et al., “Toxic dye removal, remediation, and mechanism with doped SnO2-based nanocomposite photocatalysts: A critical review,” J Water Process Eng, vol. 54, p. 104069, Aug. 2023, doi: 10.1016/j.jwpe.2023.104069.
Downloads
Published
Issue
Section
License
Copyright (c) 2026 Advanced Journal of Scientific Research
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.
